搅拌车对于装置配件主要都有什么呢？日常要怎么做处理，会容易出现什么状况，其实保持机器干净，及时调整、紧固松动的零部件，这只是其中一点要日常经常做的，下面跟着小编看还有什么其他事项吧。

What are the main parts of the mixer for the device? How to deal with it in daily life and what will happen easily. In fact, keep the machine clean, adjust and tighten loose parts in time. This is just one of the things that we should do frequently in daily life. Let's follow the editor to see what else we have to do.

检查除尘器各蝶阀与搅拌车的联动情况;主动除尘风机、除尘器反吹装置、震动器工作状态;检查吸尘管路有无破裂、吸尘管内粉尘堆积情况及清理;除尘器积料部粉尘的堆积情况和清理。

Check the linkage between each butterfly valve of the dust collector and the mixer; The working state of active dust removal fan, dust collector back blowing device and vibrator; Check whether the dust collection pipeline is broken, and the dust accumulation in the dust collection pipe and cleaning; Accumulation and cleaning of dust in the material accumulation part of the dust collector.

料斗内粘着物清缸、供气管路油杯检查加注、油水分离器积水排放五、各配电箱的防护门关闭完好，粉尘;盘点清理工具并上锁;搞好工具室、电器室环境卫生。轴端密封、轴端轴承按规定定时加注润滑脂，对同步齿轮、动力链条、动力主减速箱、动力电机轴承每班检查，按规定定时加注或更换润滑油。

Clean the adhesion in the hopper, check and fill the oil cup of the air supply pipeline, and drain the water in the oil-water separator. V. the protective door of each distribution box is closed and intact, and the dust is removed; Check and clean tools and lock them; Do a good job in environmental sanitation of tool room and electrical room. The shaft end seal and shaft end bearing shall be filled with lubricating grease regularly according to the regulations. The synchronous gear, power chain, power main reducer and power motor bearing shall be checked every shift, and the lubricating oil shall be filled or replaced regularly according to the regulations.

使用完全自动搅拌车，也要定期清理、保养，正确的使用、清理可延长搅拌机的使用寿命，要定期对搅拌车进行保养规程所规定项目的维护、保养作业，如清洗、润滑、加油等。

When using a fully automatic mixer, it is also necessary to clean and maintain it regularly. Correct use and cleaning can prolong the service life of the mixer. It is necessary to regularly carry out the maintenance and servicing of the items specified in the maintenance procedures, such as cleaning, lubrication, refueling, etc.

在冬季使用时，要注意工作完毕后应该用水清洗搅拌车滚筒并将水泵、水箱、水管内积水放净，以免水泵、水箱、水管等冻坏。要记得不能用大锤击打的办法根除积存在搅拌车筒内的混凝土，只能用凿子。

When using in winter, it should be noted that after the work is completed, the drum of the mixer truck should be cleaned with water and the accumulated water in the water pump, water tank and water pipe should be drained to avoid freezing damage of the water pump, water tank and water pipe. Remember that you can't use a sledgehammer to eradicate the concrete accumulated in the mixer drum, but only use a chisel to remove it.

搅拌车使用前要先检查各控制器是否良好，停工后用水和石子倒入搅拌筒内10~15分钟进行清洗，再将水和石子清出。操作人员如须进入搅拌筒内清洗时，除切断电源和卸下熔断器外，还需要锁好开关箱。

Before using the mixer truck, check whether each controller is in good condition. After shutdown, pour water and stones into the mixing drum for 10-15 minutes for cleaning, and then remove the water and stones. If the operator needs to enter the mixing drum for cleaning, he should not only cut off the power supply and remove the fuse, but also lock the switch box.

此外自动搅拌车满载混凝土正转时，如要反转，必须操纵手柄使正转停稳后，再操纵手柄反转。严禁正转过程中操纵手柄使其反转。在水箱没有卸压之前不可打开进水阀。卸料溜槽、加长溜槽是否需要一起使用，由具体工作位置的要求来决定。水箱没有卸压之前不可开车行驶。冬季停放时，水箱和供水系统里，不得有剩余水。非操作人员，禁止操作。

In addition, when the automatic mixer truck rotates forward with full load of concrete, if you want to reverse, you must control the handle to make the forward rotation stop stably, and then control the handle to reverse. It is strictly forbidden to reverse the joystick during forward rotation. Do not open the water inlet valve before the water tank is depressurized. Whether the discharge chute and the extended chute need to be used together depends on the requirements of the specific working position. Do not drive until the water tank is depressurized. When parking in winter, there shall be no residual water in the water tank and water supply system. Non operators are forbidden to operate.

以上就是问题解答的相关内容了，希望能够帮助到大家，如对这一问题还存在任何疑问，都欢迎关注我们网站http://www.jfhntjbc.com并咨询我们的工作人员，将竭诚为您服务。

The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://www.jfhntjbc.com And consult our staff, will serve you wholeheartedly.