如果气体循环系统在混凝土自动搅拌车的正常运行过程中发生故障，驱动力将线性下降，并且无法正常启动的现象非常严重。

If the gas circulation system breaks down during the normal operation of the automatic concrete mixer, the driving force will decline linearly, and the phenomenon that it cannot start normally is very serious.

1.混凝土自动搅拌车空压机应水平安装，固定并通风。

1. The air compressor of automatic concrete mixer should be installed horizontally, fixed and ventilated.

2.强大的抗风雨能力，不暴露在阳光下。

2. Strong weather resistance, not exposed to the sun.

3.调整气动自动开关的上限和下限。如果压力太低，气缸会减速，如果压力太高，则气动系统的气密性会降低。

3. Adjust the upper limit and lower limit of pneumatic automatic switch. If the pressure is too low, the cylinder will slow down. If the pressure is too high, the air tightness of the pneumatic system will be reduced.
               

4.使用自动上料搅拌车检查油位，并确保油位在量油尺的顶线和底线之间。当油位接近下限时，添加新油。

4. Use the automatic feeding mixer to check the oil level, and ensure that the oil level is between the top line and bottom line of the dipstick. When the oil level approaches the lower limit, add new oil.

5.确保皮带正确张紧。用手指推动皮带，使其松开约10毫米。更换传送带时，必须更换整个组以保持共同的张力。

5. Make sure the belt is properly tensioned. Push the belt with your fingers to loosen it by about 10 mm. When replacing a conveyor belt, the entire group must be replaced to maintain a common tension.

6.由于气体系统中充满油，因此需要足够量的油和足够的正常运行。只有这样，才能同时使用独立式混合器的功率来延长气体系统的使用寿命。

6. As the gas system is full of oil, it needs enough oil and sufficient normal operation. Only in this way can the power of independent mixer be used at the same time to extend the service life of gas system.

我们希望这将对自动搅拌一体化车的气动系统的维护有用。感谢您的阅读，希望以上内容对您有所帮助，如您想了解更多精彩内容请多多关注我们的网站。

We hope that this will be useful for the maintenance of pneumatic system of automatic mixer truck. Thank you for reading, I hope the above content is helpful to you, if you want to know more wonderful content, please pay more attention to our website.