您好,欢迎光临莱州聚峰机械有限公司网站! 主营自动搅拌车,搅拌一体车,自动上料搅拌车等各种规格的产品。

自动上料搅拌车生产厂家

点击拨打服务热线:4008791999

您的位置:首页 - 新闻中心 > 常见问题

定期换液压油和齿轮油是搅拌车维修必不可少的

发布时间:2022-06-15 来源:http://www.jfhntjbc.com/ 浏览量:0

概述:定期更换液压油和齿轮油是自动搅拌车维修必不可少的。这是非常关键的。更换过程中要注意。如果做得不好,会导致液压部件故障和油箱闷热。接
定期更换液压油和齿轮油是自动搅拌车维修必不可少的。这是非常关键的。更换过程中要注意。如果做得不好,会导致液压部件故障和油箱闷热。接下来,来看看相关的注意事项吧。
Regular replacement of hydraulic oil and gear oil is essential for the maintenance of automatic mixer truck. This is very critical. Pay attention during replacement. If it is not done well, it will lead to hydraulic component failure and tank heat. Next, let's take a look at the relevant precautions.
加油或换油时,必须停止发动机,否则会损坏液压系统。每次换油前,必须检查整个系统的密封性能,重新拧紧所有螺栓,必要时更换新的密封件。
When refueling or changing oil, the engine must be stopped, otherwise the hydraulic system will be damaged. Before each oil change, check the sealing performance of the whole system, retighten all bolts, and replace new seals if necessary.
严禁将不同牌号的液压油和齿轮油混用或使用不合格的油。车辆出厂时使用的机油型号显示在燃油箱标签和使用手册上。如果使用的机油与出厂时使用的机油型号不同,则必须彻底清洁液压系统。
It is forbidden to mix hydraulic oil and gear oil of different brands or use unqualified oil. The type of oil used at the time of delivery of the vehicle is shown on the fuel tank label and the instruction manual. If the oil used is different from the oil used at the factory for the first time, the hydraulic system must be thoroughly cleaned.
更换的废油应妥善存放和处理,不得随意倒出。要注意环境保护。更换新机油后,让发动机怠速运转15分钟,不要转动混合鼓,以检查机油油位是否合适。
The replaced waste oil shall be properly stored and treated, and shall not be poured out at will. Pay attention to environmental protection. After changing the new oil, let the engine idle for 15 minutes without turning the mixing drum to check whether the oil level is appropriate.
此外保证液压油清洁。搅拌运输车工作环境恶劣,一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙,就要立即停机清洗液压系统、更换液压油。
In addition, ensure that the hydraulic oil is clean. The mixer truck has a bad working environment, so it is necessary to prevent the dirty cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the manual. Once water or sediment is found in the hydraulic oil during inspection, stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
自动搅拌车
保证自动搅拌车液压油冷却装置有效。要定时清理液压油散热器,避免散热器被水泥堵塞,检查散热器电动风扇运转是否正常,防止液压油温度超标。液压部分只要保证液压油清洁,一般故障不多。
Ensure that the hydraulic oil cooling device of the automatic mixer truck is effective. Clean the hydraulic oil radiator regularly to prevent the radiator from being blocked by cement. Check whether the electric fan of the radiator operates normally to prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part.
万向转动部分是故障多发部位,应按时加注润滑脂,并经常检查磨损情况,及时修理更换。车队应有备用的万向轴总成,以保证一旦发生故障能在几十分钟内恢复工作。
The rotating part of the universal joint is the part with frequent faults, so it should be filled with grease on time, and the wear should be checked frequently and repaired and replaced in time. The fleet shall have a spare cardan shaft assembly to ensure that the work can be resumed within tens of minutes in case of failure.
希望以上所讲可以帮助到您,更多相关的信息您可以来关注我们网站http://www.jfhntjbc.com,联系客服人员,为您讲解更多更为详细的内容或者问题,让您在此有所获取!
I hope the above can help you. For more relevant information, you can follow our website http://www.jfhntjbc.com , contact the professional customer service personnel to explain more and more detailed contents or questions for you, so that you can get some information here!

截屏,微信识别二维码